Maintenance Log

DateEngine HoursEngine Oil Change (150hrs)Fuel Filter Replacement (250 hour/annually)Saildrive Oil Change (250 hour/annually)Replace ZincsRaw Water PumpWinch ServiceBottom PaintOther Description
5/12/2026Galley - Polish countertops
5/11/2026Galvanic corrosion (Cathodic) testing
5/6/2026Engine - starboard fuel tank inspection (fuel down to 25 liters) - everything clear, some black staining on bottom, no debris, and no corrosion visible in the tank (the pickup/return tubes are in a lower compartment that cannot be viewed)
4/29/2026XZincs - replace triangular zincs (port only)
4/28/2026Repair SB solar panels - remove MC4 connectors and solder directly with adhesive heatshrink and silicon tape
4/24/2026Engine - port fuel tank inspection (fuel down to 50 liters) - everything clear, some black staining on bottom, no debris, and no corrosion visible in the tank (the pickup/return tubes are in a lower compartment that cannot be viewed)
4/18/2026Holding Tank - remove, clean, and reinstall starboard holding tank - replace pumpout hose
4/17/2026Dinghy - replace dinghy wheel tube
4/16/2026Holding tank - clean Port holding tank - replace all hoses
4/9/2026Refrigerator - add drain pump and remote timer to refrigerator drain
4/9/2026Electrical - add two USB jacks to the saloon
4/9/2026Dinghy - replace lifting fiddles and add bow/stern backup safety lines
4/3/20262994.8/2993.1Engine - both engines, remove/clean injectors, replace 119717-59510 Fuel Return Pipe Assembly (damaged during removal), adjust valves (found to be 1/1000 out with 7/1000 toleranace allowed), both engines (Rafa inspected both engines and commented "Running good")
3/17/2026Holding tank - plugged, cleared obstruction in port tank
3/15/2026Rigging - tighten Port outer shroud 1.5 turns
3/14/20262980.9XEngine - tighten Starboard alternator belt
3/13/2026Rigging - replace sheeves on port line organizer
3/12/20262980.3XEngine - replace Starboard saildrive 1.3qt oil (partial)
3/6/2026Rigging - inspection by Chris with Eddie's guidance
3/5/2026Rigging - tighten SB outer shroud 1.5 turns
2/23/2026XZincs - replace triangular zincs (both)
2/3/20262929XEngine - change oil
11/6/2025Engine - tighten Starboard alternator belt
11/1/2025XZincs - replace triangular zincs (both), propeller ring (sb only)
10/30/20252805.4XEngine - replace Port raw water impeller
10/25/2025Engine - replace all raw water hoses and hose clamps (port and starboard)
10/25/2025Stanchions - Remove, clean, and rebed all stanchions the arch and behind (3m 4000UV)
10/25/2025Engine - Remove, sand, paint and reinstall engine muffler mounting brackets
10/25/2025Engine - Remove, sand, paint and reinstall engine airfilter brackets
10/25/2025Gelcoat - fix all cracks, damage, and respray
10/25/2025Gelcoat - polish entire boat and apply ceramic wax
10/20/2025Sails - replace stack pack
10/20/2025Windows - treat corrosion and paint saloon window around latches
10/11/2025Engine - Brush, sand, and touch up paint rust area on the engine and engine mounting brackets
10/11/2025Engine - inspection by Pac West
10/11/2025Windows - replace vents in forward deck hatches
10/11/2025Engine - replace exhaust elbow (port and starboard)
10/11/2025Rigging - replace jib sheet
10/11/2025Rigging - replace screecher furling line
10/11/2025Anchor - replace windlas bow switch
10/3/2025Engine - replace raw water inlet strainer
10/3/2025Gelcoat - sand and cover black painted areas with black Boat Armor film
10/3/2025Electrical - install new battery banks
10/3/2025Electrical - relocated electronics and clean up wiring for all saloon locker compartments
10/3/2025Rigging - replace screecher halyard
10/3/2025Engine - add blower fan to starboard engine compartment
10/3/2025Engine -replace bolts attaching the alternator pulley to the engine
10/3/2025Water - install shutoff valve in bow locker to spraydown fitting
10/3/2025Windows - repair/reinforce hole/cracks with fiberglass and paint interior hatch trim
9/25/2025Rigging - remove, clean, loc-tite, and tighten set screws in main sail track
9/25/2025Electrical - replace all cockpit overhead lighting fixtures
8/6/20252761.0/2761.0XEngine - oil change (Delo 15W40)
8/6/20252761.0/2761.0XSaildrive - replaced oil from inside (not full changed)
8/6/20252761.0/2761.0XEngine - replace fuel filters
8/3/2025Water - replace fresh water pump (WPS 5.0)
7/20/2025Propane - replace solenoid
6/30/2025Rigging - Jib limiter line (remove (never used), clean, store)
6/26/2025XZincs - replace triangular zincs (gone)
6/16/2025XEngine - replace Starboard raw water pump belt
5/15/2025XZincs - replace saildrive collar zincs
4/21/2025Rigging - Standing rigging - inspection and cleaning (by Allan)
3/27/2025XZincs - replace triangular zincs (gone)
3/15/20252599.0/2599.0XSaildrive - replaced oil from inside (not full changed)
3/1/20252598.0/2598.0XEngine - oil change (Delo 15W40)
2/6/2025XEngine - replace Starboard raw water pump impeller
1/15/2025Watermaker - replace membrane with AMI brand
1/15/2025XWinches - service
12/15/20242480.0/2480.0XSaildrives - replace seals, o-rings, oil
12/15/2024Hulls - clean, polish, wax
12/15/2024Propellers - replace rubber interior hubs and plastic bushings (much less slop), replace zincs, apply Prop Speed
12/15/2024Bottom paint - repair blisters and Coppercoat
12/15/2024Windows - rebed four side saloon windows with Dow 795
12/15/2024Hulls - repair blisters and damage on stern extensions
12/15/2024Hulls - Repaint all black areas
12/15/2024Electrical - install Wakespeed regulators (no crossfeed)
12/15/2024Electrical - install new Victron Charger/Inverter
10/10/2024Engine - replace Port fuel hose between Rancor/Engine and Engine/Fuel return to tank (USCG A1-15 hose) due to failure
10/10/2024Hulls - clean, polish, wax
10/3/2024Rigging - replaced traveler line (3/8" polyester double braid - huge imrpovement)
9/10/20242455.0/2455.0XEngine oil change (Delo 15W40)
8/1/2024Electrical - install Balmar 120A alternators and Wakespeed controllers on both engines (included upgrade to J10 belt)
7/31/2024XZincs - replace triangular, propellopr collar, and saildrive collar zincs
6/25/2024Engine - replace Port lower raw water hose
6/5/2024XEngine - rebuild Port raw water pump
12/1/2023HVAC - install diesel heater
11/1/2023XZincs - replace collared zincs
10/31/20232437.4/2437.4Engines - check and adjust vavle lash on both engines (only minor adjustements)
10/20/20232435.0/2435.0XReplace Port raw water pump impeller
10/14/20232430.0/2430.0XEngine - oil change (Delo 15W40)
10/14/20232430.0/2430.0XEngine - replace fuel filters
10/14/20232430.0/2430.0Engine - inspect engine mounts
10/14/20232430.0/2430.0XEngine - oil change (Delo 15W40)
10/5/2023Water - replace water heater pressure relief valve (still leaks)
10/5/2023Water - replace fresh water pump with varible speed pump
10/1/2023XZincs - replace triangular zincs
9/1/2023Holding tank - Port holding tank vent hose (removed, cleared, cleaned, installed)
8/1/2023Water - replace fresh water accummulator tank
6/20/2023XZincs - replace triangular, propellopr collar, and saildrive collar zincs
2/26/2023XZincs - replace triangular, propellopr collar, and saildrive collar zincs
10/3/20222400.0/2400.0XEngine - rebuild Starboard raw water pump
10/1/20222382.2/2372.6XEngine - oil change (Delo 15W40)
6/23/2022Saildrive - replace taper pin
6/23/2022XSaildrive - replaced oil from inside (not full changed)
6/4/2022XZincs - replace triangular, propellopr collar, and saildrive collar zincs
6/1/2022Engine - Starboard alternator bracket, upper bolt broken at block (cause lower bolt too long, replaced upper bolt and add washer to lower bolt, torque to spec)
5/12/20222263.0/2261.0XEngine - oil change (switch to Delo 15W40)
4/3/20222216XSaildrive - replaced oil from inside (not full changed)
4/3/2022Engine - tighten Starboard alternator belt
4/3/2022Water - replace galley water filter
3/24/2022Rigging - replace sheeves in aft boom (increase size by 1cm, reduce chaffing)
3/15/2022XZincs - replace triangular, propellopr collar, and saildrive collar zincs
3/8/2022Rigging - replace Main halyard shackle (Tylaska H-B 2=1)
3/8/2022Water - replace fresh water accummulator tank
3/8/2022Rigging - replace door lift line
3/8/2022Hulls - clean, wax
1/5/2022Winches - service
1/5/2022Windows - rebed four side windows with Dow 795
1/5/2022Electrical - install GFCI in galley for induction cooktop
1/5/2022Water - replace Port lav faucet
1/5/2022Saildrive - replace rubber interior hubs in both propellers
1/5/2022XBottom paint - install Coppercoat bottom paint (raise water line 2 inches)
1/5/2022Hulls - clean, polish, wax
1/5/20222116XXSaildrive - replace Port and Starboard seals, o-rings, oil, zincs
12/20/2021Windows - rebed two forward saloon hatches with Dow 795
12/20/2021Electrical - install four solar panels (flexible) on hardtops (Custom Marine Products 120W each)
12/13/20212115.6/2121.4XEngine - oil change
12/13/2021XSaildrive - replace seals, o-rings, oil
12/13/2021Replace Port and Starboard internal zincs
12/13/2021Engine - replace sea water shutoff valves with ball type
12/13/2021Water - clean raw water filters (2 engine, 2 head, 1 A/C, 1 watermaker, 1 fresh water)
12/1/2021Windows - install pulldown shades
12/1/2021Lighting - install new spreader light (LED) and steaming light (LED)
12/1/2021Rigging - replace main halyard (11mm New England brands endura)
11/28/2021Hull extensions - replace delamination of top of extensions, gel coat, and replace decking with Aqua Traction
11/20/2021Propane - replace regulator and interlock switch in galley
11/20/2021Sails - replace Main/Jib/Screecher and stack pack (Zoom sails Jamie Gifford)
11/20/2021Electronics - replace chartplotter (Raymarine Axiom 12+ RealVision)
11/20/2021Electronics - replace autopilot (Raymarine EVO)
11/20/2021Electronics - replace radar (Raymarine Quantum II)
11/20/2021Electronics - replace radio (Horizon GX1800 GPS)
11/20/2021Lighting - install dimmers on saloon
11/20/2021Entertainment - install new TV
11/20/2021Anchor - replace G4 anchor chain (300 feet) + 100 feet rode (existing)
11/20/2021Windlass - service, repair footswitch, replace chainpipe
11/20/2021Rigging - standing rigging inspection (Kim Weir OXR), no concerns
7/30/2021XSaildrives - replace zincs
6/1/2021Storage - add access hatches to greywater tanks
4/1/2021Cockpit - install cockpit hardtop inserts (from factory)
4/1/2021Cockpit - install Port helm seat (factory frame and upholstry in Oxnard)
4/1/2021Water - replace galley faucet
3/9/2021XZincs - replace triangular, propellopr collar, and saildrive collar zincs
2/22/20212056.0/2056.0XEngine - replace oil and filter
12/1/2020Windows - replace gas strut on Port front window
10/1/2020Head - replace Port toilet with Johnson electric flush
10/1/2020Lighting - install LED strip lighting in engine compartments
10/1/2020Trampolines - re-stitch/repair and install new cord
7/1/2020Electrical - install Fortune 400ah battery bank
7/1/2020Electrical - install Victron BMV712 battery monitor
10/24/2019Water - replace galley water filter
10/24/20191891.1/1899.7XEngine - replace oil and filter
10/23/2019Rigging - replace Reef 1 and reef 2 lines
10/22/20191735.4/1739.9XEngine - replace oil and filter
10/22/2019Propellers - dynamic balance Port and Starboard
10/22/2019XBottom paint - apply 2 coats plus 3 on waterline
10/22/2019Rudder bearings - replace Starboard
6/13/20191737.9/1737.9Engine - replace Starboard alternator and raw water belts
5/4/20191682.5/1682.5Engine - replace Port heat exchanger
4/13/20191662.4/1661.1XEngine - replace oil and filter
4/13/20191662.4/1661.1XSaildrive - replace seals, o-rings, oil
5/28/2018Outboard - oil change
12/18/2017Outboard - change raw water impeller
11/23/2017Engine - clean and treat rust on saildrive hardware and motor mounts
11/21/2017Lighting - replace Anchor light bulb
10/25/2017XBottom paint - strip to gelcoat, add barrier coat (West System), PPG ABC3 Ablative (2 coats plus 3 on waterline)
10/25/2017Anchor - install 65# Mantus anchor, mark chain
3/22/2017Saildrive - replace Starboard dog clutch and taper pin
2/28/2017XEngine - replace Starboard raw water impeller
1/20/2017XZinces - replace Port and Starboard internal zincs
1/20/2017Rudder bearings - replace Port and Starboard
1/20/2017Anchor - installed new anchor roller and Mantus 55# anchor
11/5/20161518.1/1517.2XEngine - replace oil and filter
11/4/20161286.1/1283.6XSaildrive - replace oil
11/3/20161286.1/1283.6XEngine - replace oil and filter
11/2/20161197XEngine - replace Port raw water pump belt
10/21/2016XBottom paint - apply one coat
10/20/20161152.0/1152.0XSaildrive - replace Port and Starboard prop shafts, seals, o-rings, oil
10/9/2016XBottom paint - apply two coats
10/9/2016Outboard - oil change
10/8/2016Water - replace galley water filter
8/12/2016Rigging - Standing rigging - inspection and cleaning
7/31/2016Rigging - replace Jib sheet
7/30/2016Rigging - replace Main sheet
7/29/2016Rigging - replace Main Halyard
7/28/2016Rigging - replace Traveler line (57 feet)
7/27/2016Rigging - replace Lazy jacks (220 feet)
7/26/2016Rigging - replace Jib halyard
7/25/20161145.5/1145.5XEngine - change oil and filter change, clean heat exchangers
7/25/2016XWinches - service
7/5/20161109.0/1109.9XSaildrive - oil change (PURCHASE SURVEY)
7/5/2016Hulls - clean, polish, wax
10/4/2012Rigging - replace Jib sheet
9/26/2012Trampolines - restitch